Skip to main content

Extension

Open Main MenuClose Main Menu

Fertilization Based on Sufficiency, Build-up and Maintenance Concept

Introduction

The primary nutrients that are deficient in Oklahoma are nitrogen (N), phosphorous (P) and potassium (K).  Fertilizer recommendations should be based on the results from soil tests that determine what type of deficiency exists in the field. When a group of producers were asked if soil testing would help improve crop yields, 82 percent responded positively. But when the same group was asked if they used soil test routinely; only 28 percent replied “yes” (Kinsey, 2002).

 

There are different approaches soil testing labs (commercial and public) and consultants may use when making fertilizer recommendations. Some laboratories use the sufficiency concept, while others use the maintenance, build-up or a combination of all three approaches. For example, Oklahoma State University has been using the sufficiency concept for immobile nutrient recommendation, while Kansas State University provides guidelines for both the sufficiency and the buildup-maintenance approach.

 

This publication describes; different approaches for making fertilizer recommendations so one can understand why there are discrepancies among the recommendations of different labs, and how to adjust fertilizer practices based on market conditions. However, Oklahoma State University Soil Testing Lab does not intend to change from the sufficiency approach.

 

Sufficiency – Fertilizing the crop, rates based on likelihood of achieving a yield response

 

Build-Maintain – Fertilizing the soil, rates based on increasing soil test values to defined level then adjusting the rate to maintain soil test values at the critical level.

 

Sufficiency Approach

The requirements for immobile nutrients are not related to yield goal, like mobile nutrients such as nitrogen and sulfur (Zhang and Raun, 2008).  Instead, the requirements of immobile nutrients are functions of the concentration of plant available nutrients in the soil. In general, a plant can only extract immobile nutrients, such as P and K, from the soils near the root surface. Thus, the amount extracted by the plant is limited by the concentration at the root-soil interface.

 

For immobile nutrients, nutrient level is presented as a percent sufficiency based on soil test value. Percent sufficiency for an immobile nutrient can be expressed as a percentage of the potential yield when the nutrient is limited and independent of the environment.   For example, the regional yield potential for winter wheat is 50 bu ac-1, but the soil test indicates the P level is 80 percent sufficient then the maximum yield you should expect is 40 bu ac-1 (50 x 0.80).

 

Each crop has a specific sufficiency index and a recommended application rate for each nutrient. The goal of the sufficiency approach is to apply enough fertilizer to maximize profitability in that given year of application, while minimizing nutrient applications and fertilizer costs at the same time. Of the management strategies, the sufficiency concept will, in general apply the least amount of total nutrient. Many remember how the sufficiency concept works by saying that it “fertilizes the crop.”

 

Yield response trials must be preformed to develop sufficiency levels.  In these trials, the point at which there is no increase in yield is identified as the critical level. Oklahoma State University used yield data collected from across Oklahoma to create the calibration table for sufficiency levels of available nutrients (SLAN). Each soil test index is associated with a sufficient level based on a critical value for each nutrient (Zhang, & Raun, 2006). Table 1 shows soil test P index, the sufficiency level and P2O5  recommendations for many of the common crops grown in Oklahoma.

 

Table 1. Phosphorus fertilizer recommendations for selected crops grown in Oklahoma using sufficiency concept based on five soil test P (STP) levels.

 Phosphorus Requirements 

STP
Test Index

Small Grains
Percent Suff
Small Grains
P2O5
(lbs/A)

Grain Sorghum
Percent Suff
Grain Sorghum
P2O5
(lbs/A)
0 25 80 40 60
10 45 60 60 50
20 80 40 80 40
40 90 20 95 20
65+ 100 0 100 0
Phosphorus Requirements    (cont.)

STP
Test Index

Corn
Percent Suff
Corn
P2O5  (lbs/A)

Cotton
Percent Suff
Cotton
P2O5
(lbs/A)

Canola
Percent Suff
Canola
P2O5
(lbs/A)
0 30 80 55 75 25 80
10 60 60 70 60 45 60
20 80 40 85 45 80 40
40 95 20 95 30 90 20
65+ 100 0 100 0 100 0

 

 

A positive aspect of the sufficiency concept is that yields are maximized while annual inputs are minimized.  However, applications will need to be made every year to maintain those yield levels. Fertilization based on sufficiency levels is well suited for short term leases.

 

Maintenance

According to the maintenance concept, nutrients that have been removed with the crop at harvest should be replaced. Fertilizer is then applied, based on the amount of nutrients removed from the field, so that the soil nutrient level is maintained (Vitosh et al., 1995).  For example, winter wheat removes 0.50 lbs of P2O5 for every bushel harvested, so a 40 bu ac-1 yield would require approximately 20 lbs P2O5 per acre, see Table 2.  The maintenance concept does not recommend application when soil nutrient levels are above the critical level. Above the critical soil test level, the soil will be able to supply the nutrients required by the crop and no fertilizer response would be expected. An assumption of the maintenance concept is that there will be no change in soil test values if crop removal is used for the maintenance rate.

 

Table 2. Estimates of nutrient removal in the harvested portion of the crop.

Crop Unit P2O5 K2O
Wheat lb/bu 0.5 0.3
Corn lb/bu 0.44 0.29
Grain Sorghum lb/cwt 0.75 0.39
Canola lb/bu 0.91 0.46
Soybean lb/bu 0.8 1.4
Alfalfa lb/ton 15 60
Cotton lb/bale 12 14

Source: IPNI http://npk.okstate.edu/documentation/various/IPNI%20Removal%20Master%20101028.pdf

 

Build-up

This approach is one where the soil, rather than the plant is fertilized. The concept is based on applying nutrients in excess of the nutrients removed by the crop to build the concentration to the point where they will not be limiting. This method of fertilization has been practiced on lands that are owned or in long-term lease to ensure that the renter will “reap the fruits” of the long-term fertilization.  One of the expected fruits is the potential of avoiding fertilization during times when fertilizer prices are high.

 

The build-up of soil test values occurs during a planned period of time, usually four to eight years (Leikham et. al, 2003). Depending on the economic situation of the farmer, the farmer might choose a slow or fast build-up of P and K. Long term build-up programs help farmers manage their finances by spreading fertilizer costs through several years.

 

Build-up and Maintenance

In most literature the concepts of build-up and maintenance are mentioned together. In the central regions, Kansas State University provides ‘build maintenance’ guidelines based on their research. The build-up and maintenance philosophy has been applied since the 1940’s (Hochmuth and Hanlon, 2010) and is most suitable for immobile nutrients like P and K (Johnston et al., 2006). This means P and K would be raised to the critical soil test levels, by applying fertilizer during a long period of time, avoiding a one-time high application rate (Johnston et al., 2006).  Once the critical soil test level is reached, fertilizer recommendations will be based on maintenance.

 

Figure 1 represents a model for a tri-state fertilizer recommendation by Ohio State University based on studies conducted during a 40-year period.  The most important component of this model is the establishment of a critical level. This critical level is the same value that is established as the 100 percent level for the sufficiency concept.

 

Build-up maintain fertilizer scheme suggested by the Ohio State University.

 

 

Figure 1. Build-up maintain fertilizer scheme suggested by the Ohio State University.

 

 

 

 

Discussion

Different labs and consultants can give different fertilizer recommendations based on the management concept used. The best approach for making fertilizer recommendations depends on several factors such as type of soil, economics and cropping systems.

 

The combination between the build-up and maintenance concept is widely used. Kansas State University has provided an excel file allowing the user to see nutrient recommendation based on both the sufficiency and build-maintenance concept. As seen in Table 3, P and K recommendations based on the build-maintenance concept are higher than the recommendations based on the sufficiency concept. The sufficiency concept recommends no P for both corn and wheat at a Mehlich 3 soil test of 25 ppm (equivalent to OSU’s STP of 50). On the other hand, the build-maintenance recommends 60 lb ac-1 of P2O5 and 65 lb ac-1 of K2O. In terms of annual input cost it is easy to see the difference.

 

Table 3. Sufficiency and build-maintenance fertilizer P and K rate recommendations for corn and wheat production.

Crop Yield goal Soil Test result   Sufficiency recommendations
    Mehlich 3 P ppm NH4OAc K ppm P2O5 lb/ac
Corn 250 15 100 25
  250 25 130 0
Wheat 40 15 100 15
  40 25 130 0
Crop Yield goal   Build-maintenance recommendations 4-yr build timeframe  
    K2O lb/ac lb/ac lb/ac
Corn 250 30 105 135
  250 0 60 65
Wheat 40 15 45 80
  40 0 0 15

 

Regardless of the approach, producers should take soil samples on a regular basis, at least every three to five years, to ensure the level of each nutrient in the soil is known and fertilizer use efficiency and yields are maximized.

 

References

Hochmuth, G. & Hanlon, E. (2010). Principles of Sound Fertilizer Recommendations. University of Florida, IFAS Extension SL315.

 

Johnston, A. (2006). Soil testing Philosophy or “How we make Fertilizer Recommendations.” Proceedings of the 2006 Direct Seeding Conference: “Managing  Risk for the Future”. Retrieved from http://www.ssca.ca/conference/conference2006/Johnston.pdf

 

Kinsey, N. (2002, May). Soil testing for soil fertility management. Retrieved from http://www.acresusa.com/toolbox/reprints/SoilTesting_Kinsey_May02.pdf

 

Leikham, D.F., Lamond R.E. and Mengel D.B (2003). Providing flexibility in Phosphorous and  Potassium Fertilizer Recommendations. Better Crops, 87: (3) pp.6-10

 

Raun, W. (2010, January). Theoretical application. Retrieved from http://soil5813.okstate.edu/INTRO_PAGE2010.htm

 

Rhine, M. & Stevens, G. (2008). Building Soil Potassium in a low- testing cotton field. Proceedings of 2008 Beltwide Cotton Conferences. Retrieved from http://www.cotton.org/beltwide/proceedings/2005-2010/data/conferences/2008/papers/7583.pdf

 

Vitosh M.L., Johson J.W., and Mengel D.B. Tri-state fertilizer Recommendation for Corn,  Soybean, Wheat and Alfalfa. Michigan State University, Ohio State University and Purdue University. Extension Bulletin E-2567. Retrieved from http://www.ces.purdue.edu/extmedia/AY/AY-9-32.pdf

 

Zhang, H.L., & Raun, B. (2006). Oklahoma Soil Fertility Handbook 2006. Oklahoma Cooperative Extension Services, Oklahoma State University.

 

Zhang, H.L., Raun, B., & Arnall, B., (2009). OSU soil test interpretations. , Oklahoma Cooperative Extension Services, Stillwater, Oklahoma. Retrieved from https://extension.okstate.edu/fact-sheets/osu-soil-test-interpretations.html

 

Natasha Macnack
Graduate Research Assistant

 

Bee Khim Chim
Graduate Research Assistant

 

Bayer Amedy
Graduate Research Assistant

 

Brian Arnall
Assistant Professor

Was this information helpful?
YESNO
Fact Sheet
Cause and Effects of Soil Acidity

Learn about how soil acidity can be a problem for plant growth in much of Oklahoma but is most prevalent in central and eastern OK. Because acid conditions are more common in eastern Oklahoma due to its natural occurrence producers are generally better able to manage soil acidity in that part of the state. In central and western Oklahoma, the soils are not naturally acidic but have become acidic overtime. This fact sheet explains why soils become acidic and the problems acid soils create for plant growth.

CropsFertilizationSoilSoil Health & Fertility
Fact Sheet
Nutrient Loss and Water Quality

The relation between nutrient loss and water quality, leaching in rural areas compared to urban and its effects on ground and surface water.

Crop Production Water IssuesFertilizationGroundwaterHome & Garden Water IssuesSoilSoil ConservationSoil MoistureWaterWater Quality
Fact Sheet
Agronomic Considerations for Industrial Hemp Production

An overview of industrial hemp production from field preparation, rules and regulations and harvesting the different products of the plant.

CropsFertilizationGrains & OilseedsSoilSoil Health & Fertility
Fact Sheet
Pre-Plant Nitrogen Response in Irrigated Corn

The affects of increasing the amount of irrigated water on corn yield.

CornCropsFertilizationGrains & OilseedsIrrigationSoilWater
VIEW ALL
Back To Top
MENUCLOSE